Dedicated to the Promotion and Preservation of American Muscle Cars, Dealer built Supercars and COPO cars. |
|
|
|
#1
05-29-2005, 06:07 PM
|
|||
|
|||
Re: HIPO GM crate engines
I remember those days, Bill...I'm hoping someone here is informed about current crate engine policy/procedure. I couldn't find anything on the Internet to confirm/deny the process these days.
SS 
|
|
#2
05-29-2005, 06:26 PM
|
||||
|
||||
|
Re: HIPO GM crate engines
I believe they still do Steve.
Chuck Hanson used to raffle off a complete brand new GM 502 Crate engine at the A.C.E.S Nashville Chevell-Abrations in the past.(He raffles off 1K cash now) I walked up to look at it,and could see it was clearly fired up at one time. Chuck had mentioned that it was tested and proved upon delivery.
|
|
#4
05-29-2005, 06:50 PM
|
|||
|
|||
|
Re: HIPO GM crate engines
We installed and briefly test fired/ran the new Ram-Jet ZL1 crate engine last Monday in my 69 Chevelle inside the shop...without a load, everything seemed fine. Then, last Friday, we pulled the Chevelle outside the shop under it's own power to set up for a road test mile or two. At high idle RPM while in gear doing a clutch/shift test in the parking lot, we suddenly heard rod noise! We immediately shut it down and yanked the engine to find EVERY rod cap nut was only speed wrench tight [less than 10 TQ] and the mains held less that 45 TQ. The rod/main bearings appear to be the only damage, but with the Memorial Holiday weekend, it'll be Tuesday before new bearings/gaskets arrive for another test run Tuesday evening.
SS
|
|
#5
05-29-2005, 06:58 PM
|
|||
|
|||
|
Re: HIPO GM crate engines
That SUCKS! I would make sure GM picks up the tab on that little brain-fart, and the best case scenario would be to just slap in a new short block...but there's probably not another RJZL-1 short block within 500 miles! I wish ya all the luck in the world...
|
|
#6
05-29-2005, 07:26 PM
|
|||
|
|||
|
Re: HIPO GM crate engines
[ QUOTE ]
...but there's probably not another RJZL-1 short block within 500 miles! [/ QUOTE ] especially tough to find in this condition... SS
|
|
#7
05-29-2005, 07:37 PM
|
||||
|
||||
|
Re: HIPO GM crate engines
WoW
 That's a cool engine Steve...have you tried looking for another engine yet? I know that Guaranty Chevrolet in Santa Ana California supplied the engines used in the TV show Overhaulin'. They have a HUGE warehouse for GM performance parts/engines... Ask for the parts manager Carl Lutes...  Guaranty Chevrolet 711 E. 17th Street Santa Ana, CA 92701 Phone (800) 569-4708 Fax (714) 973-8207
__________________
Bruce Choose Life-Donate!
|
 |
| Thread Tools | |
| Display Modes | |
|
|
Hybrid Mode
